描述

MERLIN GERIN 32570

籠型電機修理時未裝兩端蓋之前，繞組對機殼絕緣良好。裝上后，絕緣電阻降低。這種現象可判斷故障發生在繞組的兩端部。造成絕緣電阻降低的原因，可能是漆包線上漆膜有局部碰破或繞線模偏大使繞組端部伸出較長。因端蓋罩上后，端蓋內壁靠近或接觸故障點，所以使繞組絕緣電阻降低。要排除這種故障，首先應判斷故障在電機哪一端。

判斷方法是：先裝一頭端蓋，用500V絕緣電阻表測繞組的絕緣電阻，如很低，則說明這端繞組有故障存在。然后，拆下這頭端蓋，再裝上另一頭端蓋，測量繞組的絕緣電阻，如也低，則說明另一端也有故障存在。在拆、裝端蓋的過程中，轉子可不裝。確定故障端后，一般對繞組端部稍微整形一下，并涂些絕緣漆即可，如未解決問題，則可在繞組端部外側容易與端蓋內側接觸處墊上一層薄膜青殼紙，故障一般可消除。

尋找接地點的方法有如下幾點：

仔細檢查引出線和槽子兩端，發現引出線完好，槽子兩端槽口絕緣均無損壞，電機內外很干凈，各處無灰塵及油污，這說明接地點在槽內。

解開定子繞組的Y型連接點，分別測量各相對地絕緣電阻，查出有接地故障的相。

用一臺單相調壓器，其輸出端的相線接到有接地故障相的一端引出線上，零線接電機機殼，然后將調壓器從零開始升壓，至槽內冒煙，這是立即將調壓器輸出電壓將為零并切斷電源，冒煙處就是接地點。整個操作過程都要注意安全，要將電機放在一塊絕緣墊上，切斷電源前人身不能接觸電機。處理方法是：把有接地槽的槽楔小心去除，然后將電機放入烘箱內加熱，烘軟繞組，然后仔細將槽內線匝取出，檢查各導線絕緣。絕緣被破壞的要涂漆、烘干，然后重新在槽內放置槽絕緣紙，再將所取出的線匝放入槽內，打入槽楔，繞組浸漆、烘干。如發現漆包線已被燒斷，要將兩根斷線頭分別拉到繞組的端部，然后找一根線徑相同的漆包線放入槽內，在繞組兩端部接線。接頭要絞合錫焊、涂漆、烘干，再套上絕緣套管。捆扎端部時，要注意捆扎接頭。

產品承諾：
保?證?全新原裝進口,
保?證?安全準時發貨，
保?證售后服務質量，
優勢價格，大量現貨。

主營DCS系統配件
機器人系統配件
大型伺服系統配件
品牌：ABB???,AB??,GE,FOXBORO,本特利，英維思，伍德沃德，西屋，瑞恩，施耐德，西門子，摩托羅拉，安川。力士樂。ACSO，橫河等進口品牌。專業銷售進口DCS? PLC系統備件模塊
Triconex?Siemens?Yaskawa?ABB?GE?Ovation?AB?Foxboro?Motorola?Schneider?XYCOM?KUKA ? 專業銷售進口DCS? PLC系統備件模塊 15天包退換一年質保大量現貨? 國內實力庫存商家

GVG 8560 48 OUT STEREO AUDIO DISTRIBUTION AMPLIFIER DA

LAMBDA 0-60V@0-25AMPS REGULATED METERED DC POWER SUPPLY

SONY PVM-4B1U RACK MOUNT QUAD 4″ VIDEO MONITOR REBUILT!

6KW AUDIO VIDEO STUDIO AC POWER LINE VOLTAGE REGULATOR

200A 2600W CAR AUDIO POWER AMPLIFIER 12VDC POWER SUPPLY

O-13VDC 200A CAR ELECTRICAL SYSTEM TESTER POWER SUPPLY

O-13VDC 200A BOAT ELECTRICAL SYSTEM TESTER POWER SUPPLY

O-13VDC 200A CAR BOAT PLANE ELECTRICAL COMPONENT TESTER

0-200AMP DC CIRCUIT BREAKER CONNECTOR RESISTANCE TESTER

200A AC POWER LINE WIRING GROUND BOND BONDING TESTER

200AMP COPPER NICKEL CHROME ANODIZING PLATING RECTIFIER

LAMBDA 0-13V @ 0-200A DIGITAL REGULATED DC POWER SUPPLY

2NEWIB DORROUGH 40-A2 AUDIO VU LEVEL AVERAGE PEAK METER

WESTERN ELECTRIC VARIAC 4 VINTAGE TUBE AUDIO AMPLIFIER

5KW ANALOG DIGITAL AUDIO STUDIO AC POWER LINE REGULATOR

TEKTRONIX STEREO AUDIO LEVEL PHASE CD MASTERING MONITOR

NASA GEMINI ANALOG ELECTRIC DUAL STOP WATCH CLOCK TIMER

Enlarge
SR-71 BLACKBIRD FLIGHT INSTRUMENT STOP CLOCK BOMB TIMER

Enlarge
STEAMPUNK ANALOG ELECTRIC DUAL STOP WATCH CLOCK TIMER

Enlarge
NASA GEMINI FLIGHT INSTRUMENTS ANALOG STOP WATCH TIMER

Enlarge
ULTIMATE 300B TUBE AUDIO POWER AMPLIFIER POWER SUPPLY

LAMBDA EMS 13-150-2-D 0-13V@0-150A DC LAB POWER SUPPLY

VARIABLE AC POWER SOURCE SUPPLY 0-135 0-270V 50HZ 500VA

PANASONIC COLOR VIDEO MONITOR DIGITAL 4WAY MULTI CAMERA

HP 6448B 0-600V@ 0-1.5A REGULATED DC BENCH POWER SUPPLY

0-600V 1000 WATT DC POWER SUPPLY 4 TUBE AUDIO POWER AMP

DIGITAL RS-232 DATA ANNOTATOR VIDEO CHARACTER GENERATOR

0-280V@0-10A METERED ISOLATED VARIAC AC POWER SUPPLY

200AMP COPPER NICKEL SHOW CHROME GOLD PLATING RECTIFIER

HP 6268B 0-40V@0-30A REGULATED DC POWER SUPPLY GUARWKG

LAMBDA EMS 5-200-1-D 0-5V@200A DIGITAL DC POWER SUPPLY

SONY CCU-M3 4 DXC-537A DXC-M7 DXC-3000A DXC-327 CAMERA

USAMADE 0-100V@ 0-10A DIGITAL REGULATED DC POWER SUPPLY

POWER TEN 3300D-10010 0-100V@0-10A VARIABLE DC SUPPLY

SONY HKPF-D270 24P HD DIGITAL CAMERA INPUT MODULE HDCAM

SORENSEN 0-60V@0-17A REGULATED METERED DC POWER SUPPLY

TRUE ISOLATION LINE VOLTAGE REGULATOR POWER CONDITIONER

TOPAZ 70306 2KW ISOLATED AC POWER REGULATOR CONDITIONER

WOHLER 16CH STEREO AUDIO VU LEVEL METER SPEAKER MONITOR

SORENSEN 0-80V@0-12A VARIABLE REGULATED DC POWER SUPPLY

SORENSEN SRL 60-17 0-60V@0-17A METERED DC POWER SUPPLY

SORENSEN DCR 80-12B 0-80V@0-12A METERED DC POWER SUPPLY

SONY PVM-411 RACK MOUNT QUAD 4″ VIDEO MONITOR REBUILT!!

LEITCH SERIAL 601 SDI DIGITAL VIDE0 A-D 10BIT CONVERTER

LAMBDA 0-60V@ 0-18A VARIABLE REGULATED DC POWER SUPPLY

RECORDING STUDIO NO NOISE TRIPLE VARIAC LIGHTING DIMMER

SORENSEN 0-150V CIRCUIT BREAKER TESTER DC POWER SUPPLY

SORENSEN DCR 150-6B 0-150V@0-6A METERED DC POWER SUPPLY

HP 6434B 0-40V@0-25A REGULATED DC POWER SUPPLY REBUILT!

1KW BATTERY SOLAR PANEL ARRAY SIMULATOR DC POWER SUPPLY

POWER TEN 3300P-2050 0-20V@0-50A DC BENCH POWER SUPPLY

0-20V@0-50A DIGITAL REGULATED DC LAB POWER SUPPLY

50A ANODIZE ANODIZING ELECTROPLATING PLATING RECTIFIER

50A RHODIUM NICKEL SILVER GOLD ELECTROPLATING RECTIFIER

0-30V@0-33A DIGITAL REGULATED DC LAB POWER SUPPLY

POWER TEN 3300D-3033 0-30V@ 0-33A DC BENCH POWER SUPPLY

O-30V 33A PLANE ELECTRICAL SYSTEM TEST DC POWER SUPPLY

O-30V 33A AUTOMATED BURN-IN OVEN TEST DC POWER SUPPLY

0-30V DC AIRCRAFT ELECTRICAL SYSTEM TEST POWER SUPPLY

1KW EMI RFI EMISSIONS ANECHOIC CHAMBER DC POWER SUPPLY

1KW SEMICONDUCTOR WAFER PROCESS CONTROL DC POWER SUPPLY

SEMICONDUCTOR PROCESS LED LIGHT BURN IN DC POWER SUPPLY

RECORDING STUDIO NO NOISE DUAL VARIAC LIGHTING DIMMER

LAMBDA EMS 13-75-1-D 0-13V@0-75A BENCH DC POWER SUPPLY

75A ANODIZING TIN COPPER NICKEL GOLD PLATING RECTIFIER

HP 6114A 0-40V PRECISION DC CALIBRATOR LAB POWER SUPPLY

HP 6260B 0-10V@0-100A REGULATED METERED DC POWER SUPPLY

SORENSEN DCR 40-25B 0-40V@0-25A METERED DC POWER SUPPLY

HP 6428B 0-20V@0-45A VARIABLE REGULATED DC POWER SUPPLY

GENERAL RADIO 0-280V@ 0-8A DUAL METERED VARIAC LIKENEW!

45A ANODIZING ELECTRO PLATING ELECTROFORMING RECTIFIER

SIGMA VSS VIDEO AUDIO CAMERA WAVEFORM MONITOR SWITCHER

NEWBOX APS230 2CH HANDHELD DIGITAL STORAGE OSCILLOSCOPE

GVG TEN-XL VIDEO AUDIO CAMERA WAVEFORM MONITOR SWITCHER

HP 6428B 0-20V@0-45A VARIABLE REGULATED DC POWER SUPPLY

SORENSEN DCR40-25B 0-40V@ 0-25A METERED DC POWER SUPPLY

100AMP GOLD COPPER ZINC NICKEL CHROME PLATING RECTIFIER

SORENSEN 0-40V@ 0-25A REGULATED METERED DC POWER SUPPLY

STACO E1010VAW VOLTS AMPS WATTS METERS 1400W LAB VARIAC

PLC模塊，可編程控制器，CPU模塊，IO模塊，AI模塊，通訊模塊。AB/施耐德/ABB/GE/本特利/西屋/英維斯/霍尼韋爾/黑馬/FU克斯波羅

15天包退換一年質保大量現貨? 國內實力庫存商家

MERLIN GERIN 32570

描述

相關產品